Ultravation News and Information Center

How often should your UV lamps be changed and why?

The frequency of changing a UV lamp for effective indoor air quality improvement depends on how you are using the system. Typically, a UV lamp being used primarily to disinfect the air circulating through a home or small office should be replaced every 9000 hours or approximately every 12 months. For people with respiratory conditions or other acute sensitivities, we strongly recommend keeping to an annual lamp replacement schedule for the best control of airborne microorganisms and allergens.

Replacing a lamp before it literally “burns out” may seem wasteful but not when it comes to UV light. After the first year, all UV lamps by their fundamental design will have lost nearly half of their germicidal effectiveness. That’s why, for air disinfection – where the target organisms are moving with the airstream and have a short exposure time – it is critically important to keep to your one-year replacement schedule.

However, if your Ultravation® UV lamp is being used more for keeping the HVAC components clean of mold and other bio-growth, then the lamp can be replaced every two years – its maximum lifespan. This saves money (and the environment). UV lamps used for component irradiation have a stationary target: the mold or microbes that try to colonize on them. Therefore UV exposure time is much longer so less intensity is needed to prevent growth.

A UV lamp should not be kept running after 3 years. The UV system should just be turned off until the lamp is replaced, because it effectiveness is spent and it will simply waste energy. The excessive energy consumed by an aging lamp can cause the power supply to overheat, potentially causing a complete system failure.

Always remember to heed all warnings and never look at an operating UV lamp.

If you have questions or it’s time to change your lamp, contact your HVAC contractor. They are your primary source for expert consultation because they have direct experience with your particular HVAC system.

 

Find an Ultravation Authorized Contractor

Is Mold Secretly Growing in Your Home?

UV Lamp Air Disinfection

2 Responses to “How often should your UV lamps be changed and why?”

  1. ulteditor says:

    Hi Mal and thanks for your comment. It’s great that your UV lamp was clean. No accumulation of dust or debris means you probably have good filtration in your HVAC system. The lamp will not accumulate any bio-growth of course as the UV light is at it’s highest intensity there and nothing can grow. Since you have had the lamp for a year though it will have abut 40% less intensity than when it was new. Might be time to think about changing it out. Ultravation UV lamps can have adequate intensity up to two years if you are using it strictly for mold reduction on HVAC components.

  2. Mal Newbourne says:

    I am an owner with a UV unit installed.
    .
    Pulled after a year the bulb was not dirty… should it have been, with mold or ???
    .
    Mal